Salt industry by-products on lettuce growth and yield in hydroponic culture
DOI:
https://doi.org/10.3329/aajfss.v9i2.85359Keywords:
transplantation, RGR, soilless culture, nutrient solutions, physiological parameters, ascorbic acidAbstract
Lettuce (Lactuca sativa L.) is a nutrient-rich leafy vegetable commonly raw consumed and grown in soilless systems that often rely on expensive chemical fertilizers. Exploring sustainable nutrient alternatives like salt industry by-products (SIB) can reduce input costs and environmental impact. This study aimed to evaluate the effect of SIB as a partial nutrient source on lettuce growth, yield, and nutritional quality in a soilless culture system. The experiment was conducted at the Central Laboratory of Sher-e-Bangla Agricultural University, Dhaka, Bangladesh from September 2014 to March 2015. The base nutrient solution contained NO₃-N (17.05 meqL⁻¹), P (7.86 meqL⁻¹), K (8.94 meqL⁻¹), Ca (9.95 meqL⁻¹), Mg (6.0 meqL⁻¹), S (6.0 meqL⁻¹), and micronutrients Fe (3 ppm), B (0.5 ppm) , Zn (0.1 ppm) , Cu (0.03 ppm), Mo (0.025 ppm), and Mn (1 ppm). Treatments included 0 (control), 0.5 and 0.75 mlL⁻¹ SIB. The control produced the highest plant height, leaf number, breadth, length, and fresh weight, while 0.75 mlL⁻¹ SIB-treated plants exhibited the lowest growth but the highest ascorbic acid (157.61 mg/100 g) and beta-carotene (3.21 mg/100 g) contents. The 0.5 mL L⁻¹ SIB treatment resulted in moderate yield with balanced nutritional quality, indicating comparable leaf area, relative growth rate, and net assimilation rate to the control. It can therefore be concluded that 0.5 mL L⁻¹ SIB may serve as a sustainable nutrient supplement in hydroponic lettuce production. This finding emphasizes the potential of utilizing salt industry by-products as an eco-friendly and cost-effective nutrient source in soilless cultivation systems.
Asian Australas. J. Food Saf. Secur. 2025, 9(2), 67-76
Downloads
0
0
References
Balansag GVA, EM Anud, GPA Balansag, KM Anud and GNA Balansag, 2023. The effect of ab mix nutrient solution on the height, number of leaves and fresh weight of lettuce (Lactuca sativa L.) in hydroponics cultivation system. Int. J. Appl. Sci. Res., 6: 56293.
Barbosa G, FD Almeida Gadelha, N Kublik, A Proctor, L Reichelm, E Weissinger, GM Wohlleb and RU Halden, 2015. Comparison of land, water, and energy requirements of lettuce grown using hydroponic vs. conventional agricultural methods. Int. J. Environ. Res. Public Health, 12: 6879-6891.
Bisbis MB, N Gruda and M Blanke, 2018. Potential impacts of climate change on vegetable production and product quality – a review. J. Clean Prod., 170: 1602-1620.
Daşgan HY, D Yilmaz, K Zikaria, B Ikiz and NS Gruda, 2023 Enhancing the yield, quality and antioxidant content of lettuce through innovative and eco-friendly biofertilizer practices in hydroponics. Horticulturae, 9: 1274.
Gang MS, HJ Kim, TI Ahn, WJ Cho, SH Lee, JY Lee and JE Hwang, 2025. Development of nutrient management system based on ion-equivalent concentration ratio and ion monitoring to maintain ionic balance in closed hydroponic solution. Comput. Electron. Agric., 237: 110588.
Haque ME, MS Islam and MM Rahman, 2018. Use of salt industries byproduct as an alternative liquid fertilizer in floating hydroponic lettuce in Bangladesh. Bangl. J. Agric. Res., 43: 341-352.
Ishfaq M, Y Wang, M Yan, Z Wang, L Wu, C Li and X Li, 2022. Physiological essence of magnesium in plants and its widespread deficiency in the farming system of China. Front. Plant Sci., 13: 802274.
Islam MS, MM Rahman and ME Haque, 2017. Effect of salt industries byproduct as a liquid fertilizer on growth and yield of lettuce in soilless culture. SAU Research Publication. Sher-e-Bangla Agricultural University, Dhaka, Bangladesh.
Jesse SD, Y Zhang, AJ Margenot and PC Davidson, 2019. Hydroponic lettuce production using treated post-hydrothermal liquefaction wastewater (PHW). Sustainability, 11: 3605.
Jones JB Jr, 2016. Hydroponics: a practical guide for the soilless grower, 3rd edn. CRC Press, Boca Raton.
Kumar RR and JY Cho, 2014. Reuse of hydroponic waste solution. Environ. Sci. Pollut. Res., 21: 9569-9577.
Mauerer M, T Rocksch, D Dannehl, I Schuch, I Mewis, N Förster, C Ulrichs and U Schmidt, 2023. Replacing mineral fertilizer with nitrified human urine in hydroponic lettuce (Lactuca sativa L.) production. Sustainability, 15:10684.
Miransari M, S Mahdavi and D Smith, 2021. The biological approaches of altering the growth and biochemical properties of medicinal plants under salinity stress. Appl. Microbiol. Biotechnol., 105: 7201-7213.
Monsees H, J Suhl, M Paul, W Kloas, D Dannehl and S Würtz, 2019. Lettuce (Lactuca sativa, variety Salanova) production in decoupled aquaponic systems: same yield and similar quality as in conventional hydroponic systems but drastically reduced greenhouse gas emissions by saving inorganic fertilizer. PLoS ONE , 14: e0218368.
Rahman MJ and H Inden, 2012. Effect of nutrient solution and temperature on capsaicin content and yield contributing characteristics in six sweet pepper (Capsicum annuum L.) cultivars. J. Food Agric. Environ., 10: 524-529.
Rahman MJ, H Inden, M Quamruzzaman and MR Ahasan, 2017. Use of salt industries byproduct as an alternative liquid fertilizer in floating hydroponic Lettuce in Bangladesh. Int. J. Agric. Sci. Res., 7: 165-172.
Resh HM, 2022. Hydroponic food production: a definitive guidebook for the advanced home gardener and the commercial hydroponic grower. 8th edn., CRC Press, Boca Raton.
Saini RK and YS Keum, 2018. Carotenoid extraction methods: a review of recent developments. Food Chem., 240: 90-103.
Sharma N, S Acharya, K Kumar K, N Singh and OP Chaurasia, 2018. Hydroponics as an advanced technique for vegetable production: an overview. J. Soil Water Conserv., 17: 364-371.
Skrzypczak D, B Ligas, K Mikula, A Witek-Krowiak, M Samoraj, K Moustakas and K Chojnacka, 2021. Valorization of post-extraction biomass residues as carriers of bioavailable micronutrients for plants and livestock. Biomass Convers. Biorefin., 11: 3037-3052.
Slamic B and T Jug, 2016. Lettuce growth in extreme conditions. Emir. J. Food Agric., 28: 398-401.
Tavallali V, S Esmaili and S Karimi, 2018. Nitrogen and potassium requirements of tomato plants for the optimization of fruit quality and antioxidative capacity during storage. J. Food Meas. Charact., 12: 755-762.
Trejo-Téllez LI and FC Gómez-Merino, 2012. Nutrient solutions for hydroponic systems. In: Asao T (ed) Hydroponics – a standard methodology for plant biological research. Intech Open, London, pp. 1-22.
Wang L, S Guo, Y Wang, D Yi and J Wang, 2019. Poultry biogas slurry can partially substitute for mineral fertilizers in hydroponic lettuce production. Environ. Sci. Pollut. Res., 26: 659-671.
Weng X, H Li, C Ren, Y Zhou, W Zhu, S Zhang and L Liu, 2022. Calcium regulates growth and nutrient absorption in poplar seedlings. Front. Plant Sci., 13: 887098.
Wenten IG, D Ariono, M Purwasasmita and Khoirudin, 2017. Integrated processes for desalination and salt production: a mini-review. InAIP Conference Proceedings. AIP Publishing LLC, pp. 020065.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2025 Md Shariful Islam, Md Jahedur Rahman, Robiul Islam, Mohammad Zahir Ullah, Prince Biswas, Md Golam Ferdous Chowdhury
This work is licensed under a Creative Commons Attribution 4.0 International License.
